Intellihot iQ1001 Gen II Handleiding

Intellihot Ketel & boiler iQ1001 Gen II

Lees hieronder de 📖 handleiding in het Nederlandse voor Intellihot iQ1001 Gen II (80 pagina's) in de categorie Ketel & boiler. Deze handleiding was nuttig voor 61 personen en werd door 2 gebruikers gemiddeld met 4.5 sterren beoordeeld

Download PDF

Pagina 1/80

Operation & Installation Manual

iQ751, Gen II

1001, Gen IIiQ

iQ1501, Gen II

WARNING

If the information in these instructions is not followed

exactly, a or explosion could result causing re

property damage, personal injury, or death.

— Do not store or use gasoline or other ammable

vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s

instructions.

• If you cannot reach your gas supplier, call the

re department.

— Installation and service must be performed by

a installer, service agency, or the gas qualied

supplier.

— Ne pas entreposer ni utiliser d’essence ou

ni d’autres vapeurs ou liquides inammables

à proximité de cet appareil ou de tout autre

appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ

•

Ne pas tenter d’allumer d’appareil.

•

Ne touchez à aucun interrupteur; ne pas vous

servir des téléphones se trouvant dans

le bâtiment.

•

Appelez immédiatement votre fournisseur de gaz

depuis un voisin. Suivez les instructions

du fournisseur.

•

Si vous ne pouvez rejoindre le fournisseur,

appelez le service des incendies.

— L’installation et l’entretien doivent être assurés

par un installateur ou un service d’entretien

qualié ou par le fournisseur de gaz.

AVERTISSEMENT

Assurez-vous de bien suivre les instructions données

dans cette notice pour réduire au minimum le

risque d’incendie ou d’explosion ou pour éviter tout

dommage matériel, toute blessure ou la mort.

Thank you for purchasing this Intellihot unit,

Our journey to create a better heating system began back in the winter of 2005, when a tank-

type water heater brRNHGRZQDQGƠRRGHGP\EDVHPHQW%\FRPELQLng the principles of a diesel

engine’s robustness, robotics intelligence, and marine environment durability, we set out to

design a unit from the ground up ¬that would outperform and outlast all others. Quickly, our goal

grew from not just making a better water heaterEXWFUHDWLQJDQHƝFLHQWDQGLQWHOOLJHQWZDWHU

heating and delivery system.

,QQRYDWLRQLVRXUKDOOPDUNDQGVLPSOLFLW\HƝFLHQF\DQGGXUDELlity are at the core of every

lntellihot product. Our water heaters utilize the best attributes of tank and tankless – with

intelligent logic and integrated recirculation. The result is a water heating system capable

of handling the extreme loads of commercial applications with the preciseness needed for

residential applications.

Our products are proudly engineered and built in GalesburJ,OOLQRLVPDNLQJOQWHOOLKRWWKHƟUVWDQG

RQO\86EDVHGPDQXIDFWXUHURIJDVƟUHGFRQGHQVLQJWDQNOHVVZDWHr heating systems. Over

the past eight years lntellihot has helped commercial customers throughout the nation save

thousands of dollars while eliminating downtime. As we continue to expand our coverage across

North America, we strive to provide you with the same unmatched performance advantages

and savings. Our talented team of dedicated professionals is ready to assist you and help your

business succeed.

I thank you for purchasing our lntellihot products.

Sincerely,

Sridhar Deivasigamani

President, lntellihot Inc.

Table of Contents

1. General Information

1.1 Items Shipped With Water Heater. . . . . . . . . . 5

1.2 Serial Number Locations . . . . . . . . . . . . . . . . . 5

2. Safety

2.1 Safety Signal Words. . . . . . . . . . . . . . . . . . . . . 6

2.2 Installation Warnings . . . . . . . . . . . . . . . . . . . . 6

3. Technical Speci� cations

3.1 Speci cations Chart . . . . . . . . . . . . . . . . . . . . 8

3.2 High Elevation Installations . . . . . . . . . . . . . . . 8

3.3 Clearance Requirements . . . . . . . . . . . . . . . . . 9

3.4 Connection Speci cations . . . . . . . . . . . . . . . . 9

3.5 Exhaust Gas Standards . . . . . . . . . . . . . . . . . . 9

3.6 Overall Dimensions. . . . . . . . . . . . . . . . . . . . . 10

3.7 Con guration Options . . . . . . . . . . . . . . . . . . 12

4. Quick Reference Installation Guide

4.1 Install the Water Heater. . . . . . . . . . . . . . . . . 13

4.2 Pre-Startup Instructions . . . . . . . . . . . . . . . . 13

5. Preparation Before Installation

5.1 Selecting an Indoor Installation Site . . . . . . . 15

5.2 Selecting an Outdoor Installation Site . . . . . . 16

6. Gas Connection

6.1 Quick Reference Installation Instructions . . . .17

6.2 Fuel Source . . . . . . . . . . . . . . . . . . . . . . . . . . .17

6.3 Gas Pressure Requirements . . . . . . . . . . . . . .17

6.4 Gas Pressure Regulator . . . . . . . . . . . . . . . . . .17

6.4.1 Venting of Gas Supply Regulators . . . .17

6.5 Length of Gas Supply Line. . . . . . . . . . . . . . . 18

6.6 Gas Piping Material . . . . . . . . . . . . . . . . . . . . 18

6.7 Determine Correct Gas Pipe Diameter . . . . . 18

6.8 Gas Pipe Drip Leg and Shut-o Valve . . . . . . 18

6.9 Connecting Gas Line to Unit . . . . . . . . . . . . . 18

6.10 Gas Pipe Sizing Tables . . . . . . . . . . . . . . . . . . 20

7. Air Intake Inlet and Exhaust Gas Outlet

Pipe Connections

7.1 Quick Reference Installation Guide . . . . . . . . 22

7.2 Typical Single Unit Air Intake Inlet and

Exhaust Gas Outlet Pipe Installation . . . . . . . 22

7.3 Two Pipe Vent System (Direct Vent) . . . . . . 24

7.3.1 Single Unit Con gurations . . . . . . . . . 24

7.3.2 Multiple Units Con gurations . . . . . . . 24

7.3.3 Side Wall Air Intake Inlet and Exhaust

Gas Outlet Pipe Termination. . . . . . . . 25

7.3.4 Roof Air Intake Inlet and Exhaust Gas

Outlet Pipe Termination . . . . . . . . . . . 25

7.4 Single Pipe Venting System (Power Vent) . . 26

7.4.1 Single Unit . . . . . . . . . . . . . . . . . . . . . . 26

7.4.2 Multiple Units . . . . . . . . . . . . . . . . . . . 26

7.5 Combustion Air Requirements . . . . . . . . . . . . 27

7.6 Intake Air Inlet and Exhaust Gas Outlet

Pipe Diameter and Length . . . . . . . . . . . . . . 27

7.7 Venting Clearance Speci cations . . . . . . . . . 28

7.8 Exhaust Gas Outlet Pipe Materials . . . . . . . . 29

7.9 Air Intake Inlet Pipe Vent Materials . . . . . . . . 29

7.10 Recommended Exhaust Gas Outlet Pipe

Transitions . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

8. Water Connections

8.1 Quick Reference Installation Instructions . . . 31

8.2 Hot Water Connection . . . . . . . . . . . . . . . . . . 31

8.3 Cold Water Connection . . . . . . . . . . . . . . . . . 32

8.4 Condensate Drain Line. . . . . . . . . . . . . . . . . . 33

9. Electrical Power

9.1 Electrical Recommendations . . . . . . . . . . . . . 3 4

9.2 Connection Instructions. . . . . . . . . . . . . . . . . 34

10. Adjusting CO2 Level

10.1 General Information . . . . . . . . . . . . . . . . . . . . 3 5

10.2 Adjustment Procedure . . . . . . . . . . . . . . . . . . 3 5

11. Natural Gas to Propane Conversion

11.1 General Information . . . . . . . . . . . . . . . . . . . . 39

11.2 Conversion Procedure . . . . . . . . . . . . . . . . . 39

12. Operation

12.1 Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . 4 1

12.2 Turning Water Heater ON and OFF . . . . . . . . 41

12.3 Setting the Time . . . . . . . . . . . . . . . . . . . . . . 4 2

12.4 Adjusting the Water Temperature . . . . . . . . . 42

12.5 Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

12.5.1 Setting Passcode Protection . . . . . . . 43

12.5.2 Forgot Passcode . . . . . . . . . . . . . . . . . 43

12.6 iNTouch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43

12.7 Life Screen. . . . . . . . . . . . . . . . . . . . . . . . . . . 4 4

12.8 Unit Information . . . . . . . . . . . . . . . . . . . . . . . 44

12.9 More Screens. . . . . . . . . . . . . . . . . . . . . . . . . 45

12.9.1 Wi-Fi . . . . . . . . . . . . . . . . . . . . . . . . . . 45

12.9.2 Error History . . . . . . . . . . . . . . . . . . . . 45

12.9.3 telliCare Service

(Subscribe at Startup) . . . . . . . . . . . . 46

13. Connecting Multiple Units

13.1 General Information . . . . . . . . . . . . . . . . . . . . 4 8

13.2 Installation Procedure . . . . . . . . . . . . . . . . . . 48

13.2.1 telliCare for Multiple Units . . . . . . . . . 50

14. Maintenance

14.1 Side Panel Doors . . . . . . . . . . . . . . . . . . . . . . 51

14.2 Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

14.2.1 Inspection . . . . . . . . . . . . . . . . . . . . . . 51

14.2.2 Cleaning Procedure . . . . . . . . . . . . . . . 5 1

14.3 Condensate Sediment Cup Cleaning . . . . . . . 5 2

14.4 Maintenance-Free Circulation Pump. . . . . . . 53

14.5 Heat Engine Locations . . . . . . . . . . . . . . . . . . 5 3

15. Wiring Diagrams and Troubleshooting

15.1 Operational Flow Chart . . . . . . . . . . . . . . . . . 54

15.2 Complete Wiring Diagram (all models) . . . . . 55

15.3 Control Board Wiring Diagram

(iQ751 / iQ1001) . . . . . . . . . . . . . . . . . . . . . . . 56

15.4 Control Board Wiring Diagram (iQ1501) . . . . 57

15.5 Troubleshooting Guide . . . . . . . . . . . . . . . . . . 58

1 .

77 Requirements for State of Massachusetts

1 .1 7Notice Before Installation . . . . . . . . . . . . . . . 74

1 .

88 Warranty

1 .1 8Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

1 .

99 Product Warranty Card

1 .1 9Warranty Card . . . . . . . . . . . . . . . . . . . . . . . . 78

16. Serviceable Parts . . . . . . .. . . . . . . . . . . . . .. 62

Product specificaties

Merk:	Intellihot
Categorie:	Ketel & boiler
Model:	iQ1001 Gen II

Heb je hulp nodig?

Als je hulp nodig hebt met Intellihot iQ1001 Gen II stel dan hieronder een vraag en andere gebruikers zullen je antwoorden

Uw naam*

Jouw email*

Schrijf hier uw vraag

Handleiding Ketel & boiler Intellihot

Intellihot iQ2001 Gen II Handleiding

22 Juni 2023

Intellihot iQ251D Gen II Handleiding

21 Juni 2023

Intellihot iQ1501 Gen II Handleiding

20 Juni 2023

Intellihot i250 Gen II Handleiding

18 Juni 2023

Intellihot iQ251 Gen II Handleiding

17 Juni 2023

Intellihot i200 Gen II Handleiding

17 Juni 2023

Intellihot iN199 Handleiding

17 Juni 2023

Intellihot iQ3001 Gen II Handleiding

17 Juni 2023

Intellihot iN401 Handleiding

16 Juni 2023

Intellihot iQ1001 Gen II Handleiding

15 Juni 2023

Handleiding Ketel & boiler

Nieuwste handleidingen voor Ketel & boiler

Daikin EKHHE260PCV3 Handleiding

20 December 2024

Daikin EKHHE200CV3 Handleiding

20 December 2024

Daikin EKHHE200PCV3 Handleiding

20 December 2024

Daikin EKHTSU260AC Handleiding

20 December 2024

Daikin EKHTSU200AC Handleiding

20 December 2024

Daikin EKSR3PA Handleiding

20 December 2024

Daikin EKSRDS1A Handleiding

20 December 2024

Midea D80-20ED6 Handleiding

14 December 2024

Midea MWH-180ECNCR Handleiding

11 December 2024

Midea MWH-130ECNCR Handleiding

11 December 2024