Intellihot i200 Gen II Handleiding

Intellihot Ketel & boiler i200 Gen II

Lees hieronder de 📖 handleiding in het Nederlandse voor Intellihot i200 Gen II (64 pagina's) in de categorie Ketel & boiler. Deze handleiding was nuttig voor 44 personen en werd door 2 gebruikers gemiddeld met 4.5 sterren beoordeeld

Download PDF

Pagina 1/64

Operation & Installation Manual

i200, Gen II

i250, Gen II

WARNING

If the information in these instructions is not followed

exactly, a re or explosion could result causing

property damage, personal injury, or death.

— Do not store or use gasoline r other ammable o

vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Immediately call our gas uppliery s from a

neighbor’s phone. Follow the gas supplier’s

instructions.

• If you cannot reach your gas supplier, call the

re department.

— Installation and service must e performed by b

a qualied installer, service agency, or the gas

supplier.

— Ne pas entreposer ni utiliser d’essence ou

ni d’autres vapeurs ou liquides inammables

à proximité de cet appareil ou de tout autre

appareil.

QUE FAIRE SI VOUS SENTEZ GAUNE ODEUR DE Z

•

Ne pas tenter d’allumer d’appareil.

•

Ne touchez à aucun interrupteur; ne pas vous

s t tervir des éléphones se rouvant dans

le bâtiment.

•

Appelez immédiatement votre fournisseur de gaz

depuis un voisin. uivez les instructionS s

du fournisseur.

•

Si vous ne pouvez rejoindre le fournisseur,

appelez le service des incendies.

— L’installation et l’entretien doivent être assurés

par un installateur ou un service d’entretien

qualié ou par le fournisseur de gaz.

AVERTISSEMENT

Assurez-vous de bien suivre les instructions données

dans cette notice pour réduire au minimum le

risque d’incendie ou d’explosion ou pour éviter tout

dommage matériel, toute blessure u la mort. o

Thank you for purchasing this Intellihot unit.

This unit is designed for years of trouble free operation, and I urge you to read and follow the

instructions in this “Operation & Installation Manual.”

Our mission to create a better heating system began back in the winter of 2005 when a tank

water heater broke down and ooded my basement. By combining the principles of a diesel

engine’s robustness, robotics intelligence, and marine environment durability, we set out to

design a unit from the ground up that would outperform and outlast all others.

Quickly, our goal grew from not just making a better water heater, but creating an intelligent

water heating and delivery system. Innovation is our hallmark and simplicity, eciency, and

durability are at the core of every lntellihot product.

Our products are proudly engineered and built in Galesburg, Illinois. lntellihot has helped

commercial customers throughout the nation save thousands of dollars while eliminating

downtime. Our talented team of dedicated professionals is ready to assist you and help your

business succeed.

I thank you for purchasing our lntellihot products.

Sincerely,

Sri Deivasigamani

CEO, lntellihot Inc.

3 i200 / i250

Jan 2021 - Revision 01

Table of Contents

1. General Information

1.1 Items Shipped With Water Heater 5. . . . . . . . . .

1.2 Serial Number Plate Locations 5 . . . . . . . . . . . .

2. Safety

2.1 Safety Signal Words 6. . . . . . . . . . . . . . . . . . . . .

2.2 Installation Warnings 6 . . . . . . . . . . . . . . . . . . . .

3. TechnicalSpecications

3.1 SpecicationsChart ....................8

3.2 High Elevation Installations 9 . . . . . . . . . . . . . . .

3.3 ClearanceRequirements .................9

3.4 Connections ...........................9

3.5 Exhaust Gas Standards 9 . . . . . . . . . . . . . . . . . .

3.6 DimensionalSpecications .............. 10

4. Preparation Before Installation

4.1 Selecting an Indoor Installation Site . . . . . . . . 11

4.2 Selecting an Outdoor Installation Site 12. . . . . .

5. Wall Mounting

5.1 Mounting the Unit to the Wall 13 . . . . . . . . . . . .

6. Gas Connection

6.1 Quick Reference Installation Instructions 14 . . .

6.2 Fuel Source 14 ..........................

6.3 GasPressureRequirements ............. 14

6.4 Gas Pressure Regulator 14. . . . . . . . . . . . . . . . .

6.4.1 Venting of Gas Supply Regulators 14 . . .

6.5 Length of Gas Supply Pipe 14 . . . . . . . . . . . . . .

6.6 Gas Piping Material 15 . . . . . . . . . . . . . . . . . . . .

6.7 DetermineCorrectGasPipeDiameter . . . . . 15

6.8 GasPipeDripLegandShut-oValve ...... 15

6.9 Gas Pipe Sizing Tables 16. . . . . . . . . . . . . . . . . .

7. Air Intake Inlet and Exhaust Gas Outlet Pipe

Connections

7.1 Quick Reference Installation Guide 18. . . . . . . .

7.2 Typical Single Unit Air Intake Inlet and

Exhaust Gas Outlet Pipe Installation 18. . . . . . .

7.3 Two Pipe Vent System (Direct Vent) 19 . . . . . .

7.3.1 SingleUnitCongurations ......... 19

7.3.2 MultipleUnitsCongurations . . . . . . . 20

7.3.3 Side Wall Air Intake Inlet and Exhaust

Gas Outlet Pipe Termination 20. . . . . . . .

7.3.4 Roof Air Intake Inlet and Exhaust

Gas Outlet Pipe Termination 21. . . . . . . .

7.4 Single Pipe Venting System (Power Vent) 21 . .

7.4.1 Single Unit 21......................

7.4.2 Multiple Units 22 . . . . . . . . . . . . . . . . . . .

7.4.3 ConcentricVentingTermination

(Single Unit) 22 . . . . . . . . . . . . . . . . . . . .

7.4.4 ConcentricVentingTermination

(Multiple Units) 23. . . . . . . . . . . . . . . . . .

7.5 IntakeAirRequirements ................24

7.6 Intake Air Inlet and Exhaust Gas Outlet

Pipe Diameter and Length 25. . . . . . . . . . . . . . .

7.7 VentingClearanceSpecications .........26

7.8 Exhaust Gas Outlet Pipe Materials . . . . . . . . 27

7.9 Air Intake Inlet Pipe Vent Materials . . . . . . . . 27

7.10 Recommended Exhaust Gas Outlet Pipe

Transitions ...........................28

8. Water Connections

8.1 Quick Reference Installation Instructions 29 . . .

8.2 HotWaterConnection ..................29

8.3 ColdWaterConnection .................30

8.4 CondensateDrainLine ..................30

8.5 External Recirculation Options 32 . . . . . . . . . . .

9. Electrical

9.1 ElectricalCodeRequirements ............34

9.2 ElectricalConnectionandPolarity.........34

10. Adjusting CO2 Level

10.1 General Information 35. . . . . . . . . . . . . . . . . . . .

10.2 Adjustment Procedure 35. . . . . . . . . . . . . . . . . .

11. Natural Gas to Propane Conversion

11.1 General Information 38. . . . . . . . . . . . . . . . . . . .

11.2 ConversionProcedure .................38

12. Operation

12.1 ControlPanel .........................40

12.2 Turning Water Heater ON and OFF 40. . . . . . . .

12.3 Setting the Time 41 . . . . . . . . . . . . . . . . . . . . . .

12.4 Adjusting the Water Temperature 41. . . . . . . . .

12.5 Security .............................42

12.5.1 Setting Passcode Protection 42 . . . . . . .

12.5.2 Forgot Passcode 42 . . . . . . . . . . . . . . . . .

12.6 Life Screen 43...........................

12.7 Unit Information 43. . . . . . . . . . . . . . . . . . . . . . .

12.8 More Screens 44.........................

12.8.1 Error History 44 . . . . . . . . . . . . . . . . . . . .

13. Connecting Multiple Units

13.1 General Information 45 ...................

13.2 Installation Procedure 45. . . . . . . . . . . . . . . . . .

14. Maintenance

14.1 CleaningtheInletWaterStrainer .........47

14.2 Draining the Water Heater . . . . . . . . . . . . . . . 47

14.3 Filling the Water Heater 48. . . . . . . . . . . . . . . . .

15. Wiring Diagrams and Troubleshooting

15.1 OperationalFlowChart .................49

15.2 CompleteWiringDiagram(allmodels) . . . . . 50

15.3 Troubleshooting Guide . . . . . . . . . . . . . . . . . . 51

16. Serviceable Parts

17. Requirements for State of Massachusetts

17.1 Notice Before Installation 5. . . . . . . . . . . . . . . 9

18. Warranty

18.1 Warranty.............................60

19. Product Warranty Card

19.1 WarrantyCard ........................62

16.1 Electrical Components . . . . . . . . . . . . . . . . . 56

16.2 Water Lines and Fittings . . . . . . . . . . . . . . . . 57

16.3 Blower, Gas Valve . . . . . . . . 58and . . . .. . . .. . . .

16.4 Exhaust and Air Intake . . . . . . . . . . . . . . . . . . 59

16.5 Miscellaneous . . . .. . . . . . . . . . . . . . . . . . . . . . 60

Product specificaties

Merk:	Intellihot
Categorie:	Ketel & boiler
Model:	i200 Gen II

Heb je hulp nodig?

Als je hulp nodig hebt met Intellihot i200 Gen II stel dan hieronder een vraag en andere gebruikers zullen je antwoorden

Uw naam*

Jouw email*

Schrijf hier uw vraag

Handleiding Ketel & boiler Intellihot

Intellihot iQ2001 Gen II Handleiding

22 Juni 2023

Intellihot iQ251D Gen II Handleiding

21 Juni 2023

Intellihot iQ1501 Gen II Handleiding

20 Juni 2023

Intellihot i250 Gen II Handleiding

18 Juni 2023

Intellihot iQ251 Gen II Handleiding

17 Juni 2023

Intellihot i200 Gen II Handleiding

17 Juni 2023

Intellihot iN199 Handleiding

17 Juni 2023

Intellihot iQ3001 Gen II Handleiding

17 Juni 2023

Intellihot iN401 Handleiding

16 Juni 2023

Intellihot iQ1001 Gen II Handleiding

15 Juni 2023

Handleiding Ketel & boiler

Nieuwste handleidingen voor Ketel & boiler

Philips AWH1201 Handleiding

24 November 2024

Philips AWH1211 Handleiding

24 November 2024

Philips AWH1200 Handleiding

24 November 2024

Philips AWH1205 Handleiding

24 November 2024

Philips AWH1204 Handleiding

24 November 2024

Rinnai EHPA250VMAWH Handleiding

21 November 2024

Rinnai ECF29i50 Handleiding

21 November 2024

Rinnai ECF19i60 Handleiding

21 November 2024

Rinnai FM10NA Handleiding

20 November 2024

Nibe UKV 1000 Handleiding

19 November 2024